Synthesis and Structure of Ceramics of Bisubstituted M-Type Hexaferrite BaFe(11.5-x)Ti0.5AlxO19.
Keywords:
barium hexaferrite, substitution of iron with titanium and aluminum, ceramics, solid-phase synthesisAbstract
The development of scientific and technological progress is impossible without the creation of new functional materials. One of the classes of such materials are hexagonal ferrites. Their unique physical properties make them an irreplaceable material for the production of high-frequency electronics.The widespread introduction of high-frequency electronics into everyday life, over the past decade, has generated great interest in hexagonal ferrites. The number of publications devoted to the synthesis of mono- and bisubstituted ferrites noticeably increases every year.Modification of the chemical composition of a ferrite by replacing some of the iron atoms with another element, without changing its structure, leads to a change in physical properties of the material. Variation of the final ferrite properties, by changing its chemical composition, is of interest and is promising for fine tuning the material properties for a specific task.The aim of the present work is to experimentally study the possibility of synthesizing ferrite with a magnetoplumbite structure, in which the iron atoms are partially replaced by the Al and Ti atoms. A review of the scientific literature on this issue showed the absence of publications on ferrites with such a set of substitute elements.The X-ray phase and structural analysis, electron microscopy, and energy-dispersive X-ray spectroscopy were used as research methods in the present study.The article offers the results of an experimental study of the possibility of obtaining bisubstituted M-type ferrite of the BaFe(11.5-x)Ti0.5AlxO19 composition, where x (Al) = 0.1, 0.5, 1. Solid-phase synthesis has been used as a method for preparing samples. This method is devoid of technological difficulties and is promising from the point of view of its scaling for the synthesis of ferrite. The samples have been sintered at three different temperatures: 1300, 1350, and 1400 °C. It is shown that in the temperature range 1300–1400 ° C the formation of monophase samples occurs. The calculation of the parameters of the crystal lattice has been made. The influence of temperature and concentration of a substituting element on the change in the parameters of the crystal lattice of the material has been revealed.The study by the electron microscopy method made it possible to reveal the presence of latent microporosity of the samples.References
Song Y.-Y., Ordóñez-Romero C.L., Wu M. Millimeter Wave Notch Filters Based on Ferromagnetic Resonance in Hexagonal Barium Ferrites. Appl. Phys. Lett., 2009, iss. 14, vol. 95, pp. 142506. DOI: 10.1063/1.3246170
Pardavi-Horvath M. Microwave Applications of Soft Ferrites. J. Magn. Magn. Mater., 2000, vol. 215–216, pp. 171–183. DOI: 10.1016/S0304-8853(00)00106-2
Pullar R.C. Hexagonal Ferrites: A Review of the Synthesis, Properties and Applications of Hexaferrite Ceramics. Progress in Materials Science, 2012, iss. 7, vol. 57, pp. 1191–1334. DOI: 10.1016/J.PMATSCI.2012.04.001
Phan T.L., Tran N., Nguyen H.H., Yang D.S., Dang N.T., Lee B.W. Crystalline and Electronic Structures and Magnetic Properties of BaCo1-xMnxFe11O19 Hexaferrites. J. Alloys Compd., 2020, vol. 816. DOI: 10.1016/j.jallcom.2019.152528
Huang K., Yu J., Zhang L., Xu J., Li P., Yang Z., Liu C., Wang W., Kan X. Synthesis and Characterizations of Magnesium and Titanium Doped M-type Barium Calcium Hexaferrites by a Solid State Reaction Method. J. Alloys Compd., 2020, vol. 825, pp. 154072. DOI: 10.1016/j.jallcom.2020.154072
Mariño-Castellanos P.A., Anglada-Rivera J., Cruz-Fuentes A., Lora-Serrano R. Magnetic and Microstructural Properties of the Ti4+-Doped Barium Hexaferrite. J. Magn. Magn. Mater., 2004, iss. 2–3, vol. 280, pp. 214–220. DOI: 10.1016/j.jmmm.2004.03.015
Teh G., Nagalingam S., Jefferson D. Preparation and Studies of Co(II) and Co(III)-Substituted Barium Ferrite Prepared by Sol–gel Method. Mater. Chem. Phys., 2007, vol. 101, pp. 158–162. DOI: 10.1016/j.matchemphys.2006.03.008
Gultom G., Rianna M., Sebayang P., Ginting M. The effect of Mg-Al Binary Doped Barium Hexaferrite for Enhanced Microwave Absorption Performance. Case Stud. Therm. Eng., 2020, vol. 18. DOI: 10.1016/j.csite.2019.100580
Jazirehpour M., Shams M.H., Khani O. Modified Sol–Gel Synthesis of Nanosized Magnesium Titanium Substituted Barium Hexaferrite and Investigation of the Effect of High Substitution Levels on the Magnetic Properties. J. Alloys Compd, 2012, vol. 545, pp. 32–40. DOI: 10.1016/j.jallcom.2012.08.043
Rianna M., Situmorang M., Kurniawan C., Tetuko A.P., Setiadi E.A., Ginting M., Sebayang P. The Effect of Mg-Al Additive Composition on Microstructure, Magnetic Properties, and Microwave Absorption on BaFe12−2xMgxAlxO19 (x = 0–0.5) Material Synthesized from Natural Iron Sand. Mater. Lett., 2019, vol. 256. DOI: 10.1016/j.matlet.2019.126612
Alange R.C., Khirade P.P., Birajdar S.D., Humbe A. V, Jadhav K.M. Structural, Magnetic and Dielectrical Properties of Al–Cr Co-substituted M-type Barium Hexaferrite Nanoparticles. J. Mol. Struct., 2016, vol. 1106, pp. 460–467. DOI: 10.1016/j.molstruc.2015.11.004
Tsutaoka T., Tsurunaga A., Koga N. Permeability and Permittivity Spectra of Substituted Barium Ferrites BaFe12−x(Ti0.5Co0.5)xO19 (x=0 to 5). J. Magn. Magn. Mater., 2016, vol. 399, pp. 64–71. DOI: 10.1016/j.jmmm.2015.09.032
Chen J., Meng P., Wang M., Zhou G., Wang X., Xu G. Electromagnetic and Microwave Absorption Properties of BaMgxCo1−xTiFe10O19. J. Alloys Compd, 2016, vol. 679, pp. 335–340. DOI: 10.1016/j.jallcom.2016.04.001
Baniasadi A., Ghasemi A., Nemati A., Azami Ghadikolaei M., Paimozd E. Effect of Ti–Zn Substitution on Structural, Magnetic and Microwave Absorption Characteristics of Strontium Hexaferrite. J. Alloys Compd, 2014, vol. 583, pp. 325–328. DOI: 10.1016/j.jallcom.2013.08.188
Chawla S.K., Mudsainiyan R.K., Meena S.S., Yusuf S.M. Sol–gel Synthesis, Structural and Magnetic Properties of Nanoscale M-type Barium Hexaferrites BaCoxZrxFe(12−2x)O19. J. Magn. Magn. Mater., 2014, vol. 350, pp. 23–29. DOI: 10.1016/j.jmmm.2013.09.007
Soman V.V, Nanoti V.M., Kulkarni D.K. Dielectric and Magnetic Properties of Mg–Ti Substituted Barium Hexaferrite. Ceram. Int., 2013, iss. 5, vol. 39, pp. 5713–5723. DOI: 10.1016/j.ceramint.2012.12.089
Vakhitov M.G., Klygach D.S., Vinnik D.A., Zhivulin V.E., Knyazev N.S. Microwave Properties of Aluminum-substituted Barium Hexaferrite BaFe12-xAlxO19 ceramics in the Frequency Range of 32–50 GHz. J. Alloys Compd, 2020, vol. 816. DOI: 10.1016/j.jallcom.2019.152682
Setiadi E.A., Sari F.P., Sari A.Y., Ramlan R., Sebayang P. Microstuctures and Magnetic Properties of BaFe12O19 with MgO-Al2O3 Additives. Widyariset, 2016, iss. 1, vol. 2, pp. 1. DOI: 10.14203/widyariset.2.1.2016.1-8
Shams M.H., Salehi S.M.A., Ghasemi A. Electromagnetic Wave Absorption Characteristics of Mg-Ti Substituted Ba-hexaferrite. Mater. Lett., 2008, iss. 10–11, vol. 62, pp. 1731–1733. DOI: 10.1016/j.matlet.2007.09.073
Setiadi E.A., Kurniawan C., Sebayang P., Ginting M. Microstructures, Physical and Magnetic Properties of BaFe12O19 Permanent Magnets with the Addition of Al2O3-MnO. J. Phys.: Conf. Ser., 2017, vol. 817, pp. 12054. DOI: 10.1088/1742-6596/817/1/012054
Vu H., Nguyen D., Fisher J.G., Moon W.-H., Bae S., Park H.-G., Park B.-G. CuO-based Sintering Aids for Low Temperature Sintering of BaFe12O19 Ceramics. J. Asian Ceram. Soc., 2013, iss. 2, vol. 1, pp. 170–177. DOI: 10.1016/j.jascer.2013.05.002
El Shater R.E., El-Ghazzawy E.H., El-Nimr M.K. Study of the Sintering Temperature and the Sintering Time Period Effects on the Structural and Magnetic Properties of M-type Hexaferrite BaFe12O19. J. Alloys Compd, 2018, vol. 739, pp. 327–334. DOI: 10.1016/j.jallcom.2017.12.228
Vinnik D., Tarasova A., Zherebtsov D., Gudkova S., Galimov D., Zhivulin V., Trofimov E., Nemrava S., Perov N., Isaenko L., Niewa R. Magnetic and Structural Properties of Barium Hexaferrite BaFe12O19 from Various Growth Techniques. Materials, 2017, iss. 6, vol. 10, pp. 578. DOI: 10.3390/ma10060578
Vinnik D., Zhivulin V., Trofimov E., Starikov A., Zherebtsov D., Zaitseva O., Gudkova S., Taskaev S., Klygach D., Vakhitov M., Sander E., Sherstyuk D., Trukhanov A. Extremely Polysubstituted Magnetic Material Based on Magnetoplumbite with a Hexagonal Structure: Synthesis, Structure, Properties, Prospects. Nanomaterials, 2019, iss. 4, vol. 9, pp. 559. DOI: 10.3390/nano9040559
Gudkova S.A., Chernukha A.S., Vinnik D.A. The Thermal Expansion of Solid State BaFe12O19 and Flux Ba0.8Pb0.2Fe12O19 Pellets. Solid State Phenom., 2017, vol. 265, pp. 906–910. DOI: 10.4028/www.scientific.net/SSP.265.906
Townes W.D., Fang J.H., Perrotta A.J. The Crystal Structure and Refinement of Ferrimagnetic Barium Ferrite, BaFe12O19. Z. Krystallog, 1967, iss. 125, vol. 125, pp. 437–449. DOI: 10.1524/zkri.1967.125.125.437
