IMPROVING POWER AND RELIABILITY OF MULTILEVEL FREQUENCY CONVERTERS FOR DRILLING RIGS

Authors

  • A. V. Korzhov South Ural State University, Chelyabinsk, Russian Federation
  • Yu. I. Khokhlov South Ural State University, Chelyabinsk, Russian Federation
  • M. A. Grigorev South Ural State University, Chelyabinsk, Russian Federation
  • D. Yu. Khryukin South Ural State University, Chelyabinsk, Russian Federation
  • V. A. Kushnarev South Ural State University, Chelyabinsk, Russian Federation

DOI:

https://doi.org/10.14529/power210411

Keywords:

multilevel converters, reliability, electric losses, drilling rig

Abstract

Modern electric drives used in the oil and gas sector are made based on two-level power circuits for volta­ges up to 1 kV and have a modular cabinet design. The paper presents improvements based on the optimization of the number of modular frequency converters aimed at insuring smooth operation of critical oil and gas applications. Using the method of numerical analysis, the criteria for optimizing the number of phases of the power circuits of the converter in terms of cost, electrical losses and reliability were derived, based on the data on the cost of two-level frequency converters. An economic justification for reducing capital and operating costs when using multilevel frequency converters is given. It is revealed that the proposed optimization methods allow reducing electrical losses due to the reduction of overvoltages on the electromechanical converter, as well those in the DC link. The reliability increase is determined by the operability of the electromechanical converter in the event of a failure of one of its phase winding, taking into account the decrease in the installed power. The results of the introduction of multilevel frequency converters “MOMENTUM” of the MT-1000/MT-2000 series of the Scientific and Technical Center “Privodnaya Tekhnika” LLC are presented.

Author Biographies

A. V. Korzhov, South Ural State University, Chelyabinsk, Russian Federation

д-р техн. наук, профессор кафедры электрических станций, сетей и систем электроснабжения, проректор по научной работе

Yu. I. Khokhlov, South Ural State University, Chelyabinsk, Russian Federation

д-р техн. наук, профессор, кафедра электрических станций, сетей и систем электроснабжения

M. A. Grigorev, South Ural State University, Chelyabinsk, Russian Federation

д-р техн. наук, профессор, заведующий кафедрой автоматизированного электропривода, главный научный сотрудник научно-образовательного центра «Цифровая индустрия»

D. Yu. Khryukin, South Ural State University, Chelyabinsk, Russian Federation

аспирант, кафедра автоматизированного электропривода

V. A. Kushnarev, South Ural State University, Chelyabinsk, Russian Federation

студент, кафедра автоматизированного электропривода

References

ABB industrial drives ACS880 single drives Catalog. – 2015. – 55 p.

Vinogradov, A.B. Control of a multilevel frequency converter of a power-efficient electric drive /

A.B. Vinogradov, A.A. Korotkov // Russian Electrical Engineering. – 2017. – Vol. 88, no. 4. – P. 212–218. DOI: 10.3103/S1068371217040149

Применение аппарата нечеткой логики для улучшения динамических характеристик гибридных фильтров высших гармоник / Ю.К. Розанов, М.В. Рябчицкий, М.И. Смирнов, Р.П. Гринберг // Электричество. – 2007. – № 1. – С. 23–31.

Шавелкин, А.А. Анализ возможностей реализации несимметричных каскадных многоуровневых преобразователей частоты / А.А. Шавелкин // Электротехника. – 2008. – № 9. – С. 39a–45.

Садиков, Д.Г. Разработка оптимизированного алгоритма управления каскадным многоуровневым преобразователем частоты / Д.Г. Садиков, В.Г. Титов // Труды IX международной (XX Всероссийской) конференции по автоматизированному электроприводу АЭП-2016, Пермь, 03–07 октября 2016 года. – Пермь: Пермский национальный исследовательский политехнический университет, 2016. – С. 292–296.

Tu, Q. Reduced Switching-frequency modulation and circulating current suppression for modular multilevel converters / Q. Tu, Z. Xu, L. Xu // IEEE Transactions on Power Delivery. – 2011. – Vol. 26, no. 3. –

P. 2009–2017. DOI: 10.1109/TPWRD.2011.2115258

Multilevel inverter topologies with reduced device count: A review / K.K. Gupta, A. Ranjan, P. Bhatnagar et al. // IEEE Transactions on Power Electronics. –2016. – Vol. 31, no. 1. – P. 135–151. DOI: 10.1109/TPEL.2015.2405012

Steady-state analysis of interaction between harmonic components of arm and line quantities of modular multilevel converters / K. Ilves, A. Antonopoulos, S. Norrga, H. Nee // IEEE Transactions on Power Electronics. – 2012. – Vol. 27, no. 1. – P. 57–68. DOI: 10.1109/TPEL.2011.2159809

Recently Developed Reduced Switch Multilevel Inverter for Renewable Energy Integration and Drives

Application: Topologies, Comprehensive Analysis and Comparative Evaluation / P.R. Bana, K.P. Panda,

R.T. Naayagi et al. // IEEE Access. – 2019. – Vol. 7. – P. 54888–54909. DOI: 10.1109/ACCESS.2019.2913447

Повышение надежности полупроводниковых преобразователей и электроприводов объектов кислородно-конверторного производства / Ю.С. Усынин, А.М. Журавлев, И.А. Белых, Е.С. Чупин // Вестник ЮУрГУ. Серия «Энергетика». – 2016. – Т. 16, № 2. – С. 66–71. DOI: 10.14529/power160209

Published

2022-01-18

Issue

Section

Elecromechanical systems