Mathematical model of generalized heat transfer inside boiler unit furnace – heat exchange paradigm

E. V. Toropov, K. V. Osintsev

Abstract


Based on the energy conservation law the balance of heat flows in the divergent form for the two dispersion and dossipative heat transfer mechanisms is formulated. Dispersion heat entrance into the furnace is determined by the physical heat of gas flow from the area of intense burning and the chemical energy of the unburned fuel. Dissipative use of heat is determined by a variety of gradient transfer mechanisms, similar to the Fourier and Fick laws . When determining the transfer coefficients for each of the mechanisms one needs to set a generalized equation of energy conservation, which is a second order differential equation in partial derivatives, allowing for the solution with separation of variables. The application of boundary conditions of the third kind and constant initial temperature in space lets us determine the constants of integration and separation of variables and set a generalized temperature field equation in the integral form, including the dimensionless form. The set of physical and mathematical methods that put the fundamental law of energy conservation to a specific form of the temperature field from is defined as a paradigm of heat in the furnace of a boiler unit. The result of the solution for spatial temperature field characterizes the intensity of the heat in the furnace and depends on the generalized Nusselt number and then is adapted to the furnaces with the different cross-sectional area.

Keywords


furnace; heat transfer; temperature field; the Fourier method.

References


Alstom . – Available at: http://www.alstom.com (accessed 01.11.2016).

Simulation Software Products. ANSYS. – Available at: http://www.ansys.com/products (accessed 01.11.2016).

Teplovoj raschet kotlov. Normativnyj metod [Thermal Calculation of Boilers. Normative Method]. Saint Petersburg, NPO TSKTI-VTI Publ., 1998. 256 p.

Anoshin R.G., Grigor'ev K.A., Lebedev B.V. et al. [Numerical Study of Aerothermochemical Processes in Different Schemes at Various Combustion Schemes Near Moscow Coal in the Boiler Furnaces BKZ-220]. Gorenie tverdogo topliva [Burning Solid Fuels]. Novosibirsk, Institut Teplofiziki SO RAN Publ., 2006. pp. 81–87. (in Russ.)

Konyashkin V.F. [Modeling of Physical Processes in a Ring Furnace Using FLUENT Program]. Gorenie tverdogo topliva [Burning Solid Fuels]. Novosibirsk, Institut Teplofiziki SO RAN Publ., 2006. pp. 170–177. (in Russ.)

Toropov E.V., Osintsev K.V. [Adaptation of Differential Equation of the Energy to the Conditions of Furnace Processes in Boiler Units]. Bulletin of South Ural State University. Ser. Power Engineering, 2015, vol. 15, no. 1, pp. 5–10. (in Russ.) DOI: 10.14529/power150101

Toropov E.V., Osintsev K.V. [The Concept of the Flame Continuum for Zone of Intense Burning of Boiler Unit]. Bulletin of South Ural State University. Ser. Power Engineering, 2015, vol. 15, no. 3, pp. 5–10. (in Russ.) DOI: 10.14529/power150301

Toropov E.V., Osintsev K.V. [Mathematical Model of Heat Transfer into Zone the Intensive Burning Zone of Steam Generator]. Bulletin of South Ural State University. Ser. Power Engineering, 2015, vol. 15, no. 4, pp. 19–25. (in Russ.) DOI: 10.14529/power150403

Toropov, E.V. [The Systemically Structured Adaptation of Heat Transfer in Boilers]. Bulletin of South Ural State University. Ser. Power Engineering, 2016, vol. 16, no. 1, pp. 19–23. DOI: 10.14529/power160103

Toropov E.V., Osintsev K.V. [Main Characteristics of Flame Continuum Within Active Combustion Area of Boiler Unit]. Bulletin of South Ural State University. Ser. Power Engineering, 2016, vol. 16, no. 2, pp. 14–22. (in Russ.) DOI: 10.14529/power160202

Telegin A.S., Shvydkij V.S., Yaroshenko Yu.G. Teplomassoperenos [Heat and Mass Transfer]. Moscow, Akademkniga Publ., 2002. 455 p.

Shorin S.N. Teploperedacha [Heat Transfer]. Moscow, Higher School Publ., 1964. 490 p.

Isachenko V.P. Osipova V.A., Sukomel A.S. Teploperedacha [Heat transfer]. Moscow, Energoizdat Publ., 1981. 416 p.




DOI: http://dx.doi.org/10.14529/power170101

Refbacks

  • There are currently no refbacks.